aggregate ceramic replacement in concrete

آخرین محصولات

FLEXURAL BEHAVIOR OF CONCRETE BEAMS CONTAINING …

and reinforced concrete beams with ceramic waste as replacement of coarse aggregate. A total of forty-five (45) non-reinforced beams (150x150x750mm) and ten (10) reinforced beams (150x250x2150mm) were used to investigate the flexural behavior of the specimens. The flexural parameters investigated are crack formation and pattern, failure mode,

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

Investigation on ceramic waste and stone dust as aggregate ...

crushers as replacement of fine aggregate and ceramic waste as a replacement of coarse aggregate. This study was conducted to analyse the compressive and flexural strength of concrete when natural sand was replaced with stone dust at 20%, 40 %, 60%, 80 % and along with 20 % stone aggregate replacement with ceramic waste.

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

AN EXPERIMENTAL LABORATORY STUDY ON UTILIZATION OF …

ceramic waste was used as replacement for coarse aggregate. The grading of crushed ceramic tiles was done such that it was compatible with that of natural coarse aggregate. Replacement of coarse aggregate was carried out from 0%, 10%, 20%, 30%, 30%, 40% and 50 % with water to cement ratio at 0.4, 0.5 and 0.6. Comparison was made

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

SSRG International Journal of Civil Engineering (SSRG-IJCE ...

concrete as fine aggregate. The use of ceramic waste in concrete as positive effects on the environment and obtaining lower costs. In this experimental investigation, concrete mix M25 has been used. The concrete with ceramic waste as a partial replacement of fine aggregate are used and the results have been evaluated. The properties of ceramic ...

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

Effect of waste ceramic tiles as a partial replacement of ...

Hence, the crushed waste ceramic tiles were used in concrete as a replacement for natural coarse aggregates with 0%, 5%, 10%, 15% 20% and 25% of substitution. After analyzing results, the optimum value of waste ceramic tile to be used within the concrete mix with a water/cement ratio of 0.5 was determined as about 20%.

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

The Use of Ceramic Tile Waste as Aggregate in Concrete

aggregate with replacement levels of 10%, 20%, 30%, 40%, and 50%. Besides, five mixes incorporated fine crushed ceramic as partial substitute of fine aggregate with replacement levels of 20%, 40%, 60%, 80%, and . Slump test was conducted to investigate the effect of incorporating ceramic aggregates on the workability of fresh concrete.

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

CERAMIC TILES WASTE AS COARSE AGGREGATES PARTIAL ...

2.2 Ceramic Waste As partial Replacement for Course Aggregate Concrete Production 4 2.2.1 Properties of Ceramic Coarse Aggregates 5 2.2.2 Properties of Concrete That Were Made from Ceramic Waste Coarse Aggregate 6 2.2.3 Type Of Ceramic Waste 9 2.2.4 Other Application of Ceramic waste substitution 9 2.3 Aggregates 10

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

Effect of ceramic waste powder as partial fine aggregate ...

The results presented an enhancement in the mechanical properties compared with conventional concrete. Awoyera et al 17 used ceramic as a partial replacement for fine and coarse aggregate. The replacement percentages used were 25%, 50%, 75%, and for each mix as fine and coarse aggregate replacement.

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

Replacement of Fine Aggregate by Mixture of Ceramic and ...

Concrete of grade M25 was prepared at a water cement ratio of 0.45 and part of its fine aggregate was replaced by ceramic- surkhi mixture in equal proportions starting from 20% (10% ceramic + 10% surkhi) in specimen S1 for compressive strength test and specimen J1 for split cylinder test. Further the percentage of ceramic-marble mixture was ...

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

(PDF) IRJET- Replacement of stone Dust and Ceramic scrap ...

Natural coarse aggregate in concrete can be replace with ceramic waste aggregate as its properties are well within the range of specifications. Strength of ceramic concrete decreases due to many reasons such as higher flakiness, improper bonding of

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

Replacement Of Coarse Aggregate In Concrete - [Civil Planets]

Using the E-waste as a partial replacement of coarse aggregate in concrete is the best solution. We can not fully replace material in concrete because it impacts the workability of concrete. The electronic waste is crushed as required particle size and can be mixed with other aggregates in concrete which will not affect the quality & durability ...

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

Experimental Analysis on Concrete by Partial Replacement ...

concrete as a replacement for fine aggregate which is getting costlier nowadays. Ceramic tile waste is found as an effective alternate and supplementary material in concrete with the optimum replacement of 40%. (Hitesh Kumar, et al., Aug 2015) [8].The optimum percentage of concrete with ceramic tile waste for coarse and fine

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

(PDF) " PARTIAL REPLACEMENT OF AGGREGATE WITH …

" PARTIAL REPLACEMENT OF AGGREGATE WITH CERAMIC TILE IN CONCRETE " PACE INSTITUTE OF TECHNOLOGY AND SCIENCES ... Study on the Engineering Properties of Marble Waste Powder from Hyderabad Marble Market Sindh Pakistan for Making Concrete Including Recycled Coarse Aggregates.

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

Experimental Study on the Behaviour of Ceramic Waste as ...

The replacement levels of sand by ceramic waste aggregate were used in terms of 10%, 20%, 30%,40% and 50% in concrete.In order to study the effect of replacement of sand in various ratio of ceramic waste, cube of 15x150x150 mm size, beams of size 100 mm x …

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

Partial Replacement of Waste Foundry Sand by Fine ...

Partial Replacement of Waste Foundry Sand by Fine Aggregate and Waste Ceramic Tiles by Coarse Aggregate in Concrete Prof. B.Rama Rao1 CH. Anuradha2 1Professor 2P.G. Student 1,2Department of Civil Engineering 1,2Pydah College of Engineering and Technology Abstract—Concrete is one of the most vital and common materials used in the construction ...

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

EFFECT OF PARTIAL REPLACEMENT OF COARSE AGGREGATE …

The slump is taken for each mixing of concrete with replacement 10%, 20%, 30% of Ceramic tiles and 20%, 30%, 40% replacement of GGBS. The results show that slump of concrete made with natural aggregates is higher while the concrete with replacement of Ceramic tiles has less slump. The low slump in Ceramic tiles is caused by the low water ...

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

PARTIAL REPLACEMENT OF AGGREGATE WITH CERAMIC …

concrete at 25% of roof tile aggregate replacement. The workability of roof tile waste concrete is medium. To recapitulate, the replacement of tiles in concrete is suitable for small constructions The ceramic waste adopted is broken tiles. Ceramic waste concrete made with these tiles at 0%, 15%, 20%, 25% and 30%. M20 grade concrete is adopted ...

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

Partial Replacement of Aggregates with Ceramic Tiles and ...

to the coarse aggregates and fine aggregate. The ceramic waste crushed tiles were partially replaced in place of coarse aggregates by 10%, 20%, 30%, 40% and 50%. Rebutted tyre waste and ceramic tile powder were replaced in place of fine aggregate by 10% along with the ceramic coarse tile. M25 grade of concrete was designed and tested.

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

AN EXPERIMENTAL ANALYSIS OF PARTIAL REPLACEMENT OF …

and ceramic tile waste concrete for compressive strength test. The results obtained for the compressive strength of Conventional concrete and ceramic tile waste aggregate concrete with coarse aggregate for 3 days, 7 days and 28 days are shown in Table 3. SL.No %Replacement Age in Days 3 days 7 days 28 days 1 0% ngth A

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

Ceramic tiles waste as coarse aggregates partial ...

In accordance with conservation efforts, this research focuses on ceramic tile waste as partial coarse aggregates replacement for concrete production, prevention of environmental pollution with considering the elements of sustainable and cost-saving construction projects, especially material usage. Moreover, many of the construction industry in Malaysia produce construction waste that ...

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

Materials | Free Full-Text | Properties of Concrete ...

Many researchers also modified inorganic materials and admixtures in concrete with SCA to enhance the adhesion between the concrete and gelling materials and improve the macroscopic mechanical performance of the concrete, e.g., coarse ceramic vase aggregate, recycled concrete aggregate, metakaolin, and coal flying ash cenosphere .

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

Ceramic Waste : Effective Replacement Of Cement For ...

Ceramic waste can be used in concrete to improve its strength and other durability factors. Ceramic waste can be used as a partial replacement of cement or as a partial replacement of fine aggregate sand as a supplementary addition to achieve different properties of concrete.

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

Partial Replacement of Cement in Concrete using Ceramic ...

After recycling ceramic waste can be used in different construction application. Researches used ceramic waste to generate green concrete by using 20% replacement of natural aggregate. It can be shown that the concrete produce from ceramic waste is good workable and achieve characteristic strength [9, 10, 11, 12].

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

EXPERIMENTAL STUDY ON CONCRETE BY PARTIAL …

ceramic tile waste as partial coarse aggregates replacement towards compressive strength of concrete. viii) To determine the water absorption of ceramic aggregate concrete containing various content of ceramic tile as partial coarse aggregates replacement material. ix) To find the optimum proportion (10%, 20% &

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

Replacement of Coarse and Fine Aggregate by waste Ceramic ...

Replacement of Coarse and Fine Aggregate by waste Ceramic Tiles and Ceramic Powder in Concrete B.Magesh Assistant professor, Department of Civil Engineering, Peri Institute of Technology, Chennai-600048, India. M.Jayagopal Assistant professor, Department of Civil Engineering, Peri Institute of Technology, Chennai-600048, India.

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

Experimental studies on the strength of cement concrete ...

Experimental studies on the strength of cement concrete with partial replacement of coarse aggregate with ceramic tiles and cement with silica fume Rashidul Islam islamrashid22@gmail Lovely Professional University, Phagwara, Punjab Anshul Garg [email protected] Lovely Professional University, Phagwara, Punjab ABSTRACT

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

STRENGTH BEHAVIOR OF CONCRETE BY PARTIAL …

concrete materials were decided to reuse industrial waste such as Copper Slag as fine aggregate replacement in range of 10%, 20%, 30% by weight of sand and the Ceramic Waste (Tile & Shabath Stone waste) as Coarse Aggregate replacement in 10%, 20%, 25% and 20%, 30%, 35% by weight of coarse aggregate. Totally 180-cubes

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

Partial Replacement of Coarse Aggregate with Broken ...

Partial Replacement of Coarse Aggregate with Broken Ceramic Tiles in Concrete Production Yiosese A. O., Ayoola A. R., Ugonna M. C., Adewale A. K. Abstract— The study reports on experimental investigation on the suitability of the use of broken tiles as partial replacement for crushed granite in concrete production.

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

VALLUR,PRAKASAM(Dt).

powder are used as a replacement to the coarse aggregates and fine aggregate. The ceramicwaste crushed tiles were partially replaced in place of coarse aggregates by 10%, 20%, 30%, 40% and 50%.Granite powder and ceramic tile powder were replaced in place of fine aggregate by 10% along with the ceramic coarse tile. M25

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

Comparative Study on Marshall Characteristics of ...

Gazi Mohammad Harun-Or-Rashid, Abdullah Al Mamun, Isfaq Eashir Epu, Comparative Study on Marshall Characteristics of Bituminous Mixes by Partial Replacement of Foundry Sand and Ceramic Tile Dust as Fine Aggregate, American Journal of Materials Synthesis and Processing. Vol. 5, No. 1, 2020, pp. 10-16.

كوبي اولیه برای مرحله خوب مخرب، regrinding، و به عنوان مرحله…

محصولات مرتبط